FORT VALLEY HEALTH AND REHAB

Observed no paper towels at hand washing sink. 511-6-1.07(3)(b) - Hand Drying Provision (Pf) (b) Hand Drying Provision. Each handwashing sink or group of adjacent handwashing sinks shall be provided with: 1. Individual, disposable towels; Pf 2. A continuous towel system that supplies the user with a clean towel; Pf 3. A heated-air hand drying device; Pf or 4. A hand drying device that employs an air-knife system that delivers high velocity, pressurized air at ambient temperatures. Pf C/A: Person on duty was informed to refill dispenser during inspection.

Observed dishwashing machine and 3 compartment sanitizer concentration too low to be measured by testing kit. 511-6-1.05(8)(b) - Hot Water and Chemical-Methods(P) (b) Hot Water and Chemical. After being cleaned, equipment food-contact surfaces and utensils shall be sanitized in: 1. Hot water manual operations by immersion for at least 30 seconds in water at a temperature of 171°F (77°C) or above; P 2. Hot water mechanical operations by being cycled through equipment that is set up as specified under subsections (6)(e), (l), and (m) of this Rule and achieving a utensil surface temperature of 160ºF (71ºC) as measured by an irreversible registering temperature indicator; P or 3. Chemical manual or mechanical operations, including the application of sanitizing chemicals by immersion, manual swabbing, brushing, or pressure spraying methods, using a solution as specified under subsection (6)(n) of this Rule. Contact times shall be consistent with those on EPA-registered label use instructions by providing: (i) Except as specified under paragraph 3(ii) of this subsection, an contact time of at least 10 seconds for a chlorine solution specified under subsection (6)(n)1 of this Rule; P (ii) A contact time of at least seven seconds for a chlorine solution of 50 ppm that has pH of 10 or less and a temperature of at least 100ºF (38ºC) or a pH of 8 or less and a temperature of at least 75ºF (24ºC); P (iii) A contact time of at least 30 seconds for other chemical sanitizing solutions; P or.

Observed chicken hot holding between temperatures of 113F (10am) and 125F (10:25am). Item was removed from steam table and reheated on stove to 165F. 511-6-1.04(6)(f) - Time/Temperature Control for Safety; Hot Holding (P) (f) Time/Temperature Control for Safety Food, Hot and Cold Holding. Except during preparation, cooking, or cooling, or when time is used as the public health control, time/temperature control for safety food shall be maintained at 41°F (5°C) or below or 135°F (57°C) or above, except that roasts cooked to a temperature and for a time specified in subsection (5)(a)2 of this Rule and reheated using the same temperature and time conditions as cooking may be held at a temperature of 130°F (54°C) or above. P C/A: Item was reheated on stove to 165F.

Observed dishwashing machine sanitizer concentration too low to be measured by testing kit. 511-6-1.05(8)(b) - Hot Water and Chemical-Methods(P) (b) Hot Water and Chemical. After being cleaned, equipment food-contact surfaces and utensils shall be sanitized in: 1. Hot water manual operations by immersion for at least 30 seconds in water at a temperature of 171°F (77°C) or above; P 2. Hot water mechanical operations by being cycled through equipment that is set up as specified under subsections (6)(e), (l), and (m) of this Rule and achieving a utensil surface temperature of 160ºF (71ºC) as measured by an irreversible registering temperature indicator; P or 3. Chemical manual or mechanical operations, including the application of sanitizing chemicals by immersion, manual swabbing, brushing, or pressure spraying methods, using a solution as specified under subsection (6)(n) of this Rule. Contact times shall be consistent with those on EPA-registered label use instructions by providing: (i) Except as specified under paragraph 3(ii) of this subsection, an contact time of at least 10 seconds for a chlorine solution specified under subsection (6)(n)1 of this Rule; P (ii) A contact time of at least seven seconds for a chlorine solution of 50 ppm that has pH of 10 or less and a temperature of at least 100ºF (38ºC) or a pH of 8 or less and a temperature of at least 75ºF (24ºC); P (iii) A contact time of at least 30 seconds for other chemical sanitizing solutions; P or (iv) A contact ti.

Observed no paper towels at hand washing sink and employee restroom. 511-6-1.07(3)(b) - Hand Drying Provision (Pf) (b) Hand Drying Provision. Each handwashing sink or group of adjacent handwashing sinks shall be provided with: 1. Individual, disposable towels; Pf 2. A continuous towel system that supplies the user with a clean towel; Pf 3. A heated-air hand drying device; Pf or 4. A hand drying device that employs an air-knife system that delivers high velocity, pressurized air at ambient temperatures. Pf C/A: Paper towels refilled during inspection.

Observed water damaged ceiling tile throughout kitchen and dry storage. 511-6-1.07(5)(a),(b) - Good Repair, physical facilities maintained; Cleaning, Frequency & Restrictions, cleaned often enough to keep them clean (C) (5) Maintenance and Operation. (a) Good Repair. All physical facilities shall be maintained in good repair. Corrective action: Spoke to PIC to have tiles replaced and any areas where leaking is causing damage repaired.

Observed employee restroom "Out of Service" during inspection. Employees are using restroom located in other areas of the facility. 511-6-1.07(5)(a),(b) - Good Repair, physical facilities maintained; Cleaning, Frequency & Restrictions, cleaned often enough to keep them clean (C) (5) Maintenance and Operation. (a) Good Repair. All physical facilities shall be maintained in good repair. C/A: Schedule maintenance for employee restroom.

Observed three compartment sink at kitchen (close to dishwasher), leaking from the faucet and difficult to properly shut off. 511-6-1.06(2)(r) - System Maintained in Good Repair (P, C) (r) System Maintained in Good Repair. A plumbing system shall be repaired according to law; P and maintained in good repair. Corrective action: Spoke to PIC about having faucet checked and fixed.

Observed water damaged ceiling tile throughout kitchen and dry storage. 511-6-1.07(5)(a),(b) - Good Repair, physical facilities maintained; Cleaning, Frequency & Restrictions, cleaned often enough to keep them clean (C) (5) Maintenance and Operation. (a) Good Repair. All physical facilities shall be maintained in good repair. (b) Cleaning, Frequency and Restrictions. 1. The physical facilities shall be cleaned as often as necessary to keep them clean and by methods that prevent contamination of food products. 2. Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of food is exposed, such as after closing. 3. If present, playground equipment and associated areas shall be maintained in a clean and sanitary condition. In addition, a cleaning and sanitizing plan along with cleaning and sanitizing records for playground equipment and associated areas shall be maintained within the food service establishment for review upon request by the Health Authority. Further, such cleaning and sanitizing plan for employees to follow in the event of encountering vomitus or fecal matter shall be included and submitted at the time of permit application as specified in DPH Rule 511-6-1-.02(1)(c). Pf Corrective action: Spoke to PIC to have tiles replaced and any areas where leaking is causing damage repaired. They have been ordered.